[ Navy Training System Plans ]
APPROVED
NAVY TRAINING SYSTEM PLAN
FOR THE
AGM-65F INFRARED MAVERICK MISSILE
N88-NTSP-A-50-8501B/A
APRIL 1999
N88-NTSP-A-50-8501B/A
AGM-65F INFRARED MAVERICK MISSILE
EXECUTIVE SUMMARY
The U.S. Air Force is the Executive Service for development of the AGM-65 Maverick Missile System series. In October 1978, the Air Force began engineering development of the Air Force Infrared (IR) Maverick AGM-65D, and in 1980 the Navy started development of the Navy AGM-65F IR Maverick utilizing a modified IR tracker from the Air Force AGM-65D Guidance and Control Section (GCS) and the Center-Aft Section (CAS) from the Navy AGM-65E. The AGM-65F IR Maverick Missile is currently in the Operational Support Phase of the Weapon System Acquisition Process.
The AGM-65F IR Maverick Missile is designed primarily for use against targets requiring instantaneous or delayed blast fuzing for destruction of hardened ground and waterborne targets during day or night operations and in adverse weather conditions, with sufficient standoff range to permit limited exposures to terminal defenses. The IR Maverick does not replace any weapons in the current inventory.
The IR Maverick does not affect current manning levels or existing Navy Enlisted Classification codes and Marine Corps Military Occupational Specialties. Manpower requirements at the organizational, intermediate, and depot level maintenance activities are based upon total workload requirements for a specific work center, and the skills needed to perform maintenance on the systems supported by that work center.
The IR Maverick operator training is provided at the appropriate Fleet Readiness Squadrons for P-3C pilot and Naval Flight Officer personnel, for F/A-18 pilot and Weapons System Officer personnel, and for AV-8B pilots. Marine Air Weapons Training Squadron One (MAWTS-1), Strike Fighter Weapons School (SFWS) Atlantic, and SFWS Pacific provide aircrew tactics training. Navy and Marine Corps F/A-18 weapons loading training is provided by SFWS. Fleet Aviation Specialized Training Group Atlantic (FASOTRAGRULANT) Detachment Jacksonville provides P-3C loading training on the East Coast. Fleet Replacement Enlisted Skills Training (FREST) 203 provides AV-8B weapons loading training. Intermediate level training is provided to Navy and Marine Corps aviation ordnance personnel at the appropriate Naval Air Maintenance Training Group (NAMTRAGRU) Detachment.
AGM-65F INFRARED MAVERICK MISSILE
TABLE OF CONTENTS
Page
Executive Summary i
List of Acronyms iii
Preface vi
PART I - TECHNICAL PROGRAM DATA
A. Title-Nomenclature-Program I-1
B. Security Classification I-1
C. Manpower, Personnel, and Training Principals I-1
D. System Description I-2
E. Developmental Test and Operational Test I-2
F. Aircraft and/or Equipment/System/Subsystem Replaced I-2
G. Description of New Development I-2
H. Concepts I-4
I. On-Board (In-Service) Training I-11
J. Logistics Support I-13
K. Schedules I-14
L. Government Furnished Equipment and Contractor Furnished Equipment Training Requirements I-15
M. Related NTSPs and Other Applicable Documents I-15
PART II - BILLET AND PERSONNEL REQUIREMENTS II-1
PART III - TRAINING REQUIREMENTS III-1
PART IV - TRAINING LOGISTICS SUPPORT REQUIREMENTS IV-1
PART V - MPT MILESTONES V-1
PART VI - DECISION ITEMS/ACTION REQUIRED VI-1
PART VII - POINTS OF CONTACT VII-1
LIST OF ACRONYMS
AGM Air-to-Ground Missile
AIMD Aircraft Intermediate Maintenance Department
AIP Anti-Surface Warfare Improvement Program
AMIST Aviation Maintenance In-Service Training
AMTCS Aviation Maintenance Training Continuum System
AO Aviation Ordnanceman
AUR All-Up-Round
CANTRAC Catalog of Navy Training Courses
CAS Center-Aft Section
CEST Classroom Explosive Ordnance Disposal System Trainer
CIN Course Identification Number
CINCLANTFLT Commander in Chief, Atlantic Fleet
CINCPACFLT Commander in Chief, Pacific Fleet
CMC Commandant of the Marine Corps
CNET Chief, Naval Education and Training
CNO Chief of Naval Operations
COMOPTEVFOR Commander, Operational Test and Evaluation Force
CWTPI Conventional Weapons Technical Proficiency Inspection
DA Developing Agency
DOP Designated Overhaul Point
DMSO Director of Major Staff Office
DT&E Development, Test, and Evaluation
EOD Explosive Ordnance Disposal
EODTEU Explosive Ordnance Disposal Training and Evaluation Unit
FASOTRAGRULANT Fleet Aviation Specialized Training Group Atlantic
FDSU Fuze Delay Select Unit
FMS Foreign Military Sales
FRS Fleet Readiness Squadron
FREST Fleet Replacement Enlisted Skills Training
FY Fiscal Year
GCS Guidance and Control Section
HAS Hydraulic Actuation System
ILSP Integrated Logistics Support Plan
IOC Initial Operational Capability
IR Infrared
N88-NTSP-A-50-8501B/A
LIST OF ACRONYMS (Continued)
JRB Joint Reserve Base
MALS Marine Aviation Logistics Squadron
MATMEP Maintenance Training Management Evaluation Program
MAWTS-1 Marine Air Weapons Training Squadron One
MCAS Marine Corps Air Station
MCCDC Marine Corps Combat Development Command
META Maverick Engagement Training Aid
MOS Military Occupational Specialty
MTIP Maintenance Training Improvement Program
MTU Maintenance Training Unit
NALC Naval Ammunition Logistics Code
NAMTRAGRU Naval Air Maintenance Training Group
NAS Naval Air Station
NATEC Naval Air Technical Data and Engineering Command
NATTC Naval Air Technical Training Center
NAVAIRSYSCOM Naval Air System Command
NAVPERSCOM Navy Personnel Command
NAVSCOLEOD Naval Explosive Ordnance Disposal School
NAVSURFWARCEN Naval Surface Warfare Center
NAWMP Naval Airborne Weapons Maintenance Program
NAWMU Naval Airborne Weapons Maintenance Unit
NAWCWD Naval Air Warfare Center, Weapons Division
NEC Navy Enlisted Classification
NFO Naval Flight Officer
NTSP Navy Training System Plan
NWS Naval Weapons Station
OPNAV Office of the Chief of Naval Operations
OPNAVINST Office of the Chief of Naval Operations Instruction
OPO OPNAV Principal Office
OT Operational Testing
OATMS OPNAV Aviation Training Management System
PDA Principal Development Activity
PEO Program Executive Officer
PEST Practical Explosive Ordnance Disposal System Trainer
PMA Program Manager Air
PSP Phased Support Plan
PTT Part Task Trainer
N88-NTSP-A-50-8501B/A
LIST OF ACRONYMS (Continued)
RFI Ready For Issue
RFT Ready For Training
RSP Rendering Safe Procedure
SFWS Strike Fighter Weapons School
SRA Shop Replaceable Assembly
SWIP System Weapon Improvement Program
TA Training Agency
TACAIR Tactical Aircraft
TD Training Devices
TFS Total Force Structure
TGM Training Guided Missile
TSA Training Agency
TSM Training System Manager
TTE Technical Training Equipment
WSO Weapon System Officer
N88-NTSP-A-50-8501B/A
AGM-65F INFRARED MAVERICK MISSILE
PREFACE
This Navy Training System Plan (NTSP) for the AGM-65F Infrared (IR) Maverick Missile was prepared by Naval Air Systems Command as part of the regular NTSP update process within the guidelines as set forth in the Navy Training Requirements Documentation Manual, OPNAV Publication P-751-1-9-97. This NTSP reflects the changes that have occurred since the approved Navy Training Plan (NTP), AGM-65F IR Infrared Maverick Missile NTP dated 7 February 1989.
The major changes and updates to this NTSP consist of:
PART I This part shows the deletion of outdated information; incorporation of changes to formal training; updated Training Device allocation listings; identification of "A" School Core and Strand training; "C" School Initial and Career training; deletion and relocation of training sites due to decisions made by the Base Realignment Commission; the impacts of Marine Corps Military Occupational Specialty consolidations; and the addition of the IR Maverick missile to the P3 aircraft.
PART II This part has been recalculated to depict current billet requirements of fleet support units through FY02.
PART III In addition to reflecting the changes mentioned above, this part has been recalculated to depict chargeable student billets through FY02.
PART IV This part has been updated to reflect changes in training and training logistics support requirements.
PART V This part has been updated to include major milestones.
PART VI No changes.
PART VII This part has been updated to reflect current Points of Contact.
April 1999
PART I - TECHNICAL PROGRAM DATA
A. TITLE-NOMENCLATURE-PROGRAM
1. Title-Nomenclature-Acronym. AGM-65F IR Maverick Missile
2. Program Element. 0603313N, Appropriation Code 1507N42MV
B. SECURITY CLASSIFICATION. Security information for this program is contained in Air Force System Document AGM-65 Missile System, WS D/E/F/G Maverick Security Classification Guide for AGM-65 Missile System (WS-319 D/E/F/G) (Maverick) dated 1 August 1995.
C. MANPOWER, PERSONNEL, AND TRAINING PRINCIPALS
OPNAV Principal Official (OPO) Program Sponsor CNO (N880D)
OPO Resource Sponsor CNO (N880D)
Marine Corps Program Sponsor CMC (APW-23)
Developing Agency (DA) PEO TACAIR (PMA-242)
Training Agency (TA) CINCLANTFLT
CINCPACFLT
CNET
MCCDC
Training Support Agency (TSA) NAVAIRSYSCOM (PMA-205)
Manpower and Personnel (M&P) Mission Sponsor CNO (N1)
NAVPERSCOM (NPC-4, NPC-404)
Director of Naval Training CNO (N7)
Marine Corps Combat Development Command (MCCDC)
Manpower Management TFS Division
D. SYSTEM DESCRIPTION
1. Operational Uses. The AGM-65F IR Maverick Missile, hereafter referred to as IR Maverick, was designed primarily for destruction of hardened ground and waterborne targets during day or night operations and in adverse weather conditions, with sufficient standoff range to permit limited exposures to terminal defenses. The IR Maverick's host aircraft are the F/A-18 equipped with AAS-38A/B Forward Looking Infrared Radar (FLIR), the P-3C Anti-Surface Warfare Improvement Program (AIP), and the AV-8B.
2. Foreign Military Sales. Italy is a Foreign Military Sales (FMS) participant, Case IT-D-YIF.
E. DEVELOPMENTAL TEST AND OPERATIONAL TEST
1. Development, Test, and Evaluation. The Development, Test, and Evaluation (DT&E) launch phase started in May 1983 and was completed in November 1983. DT&E was conducted by Naval Air Warfare Center Weapons Division (NAWCWD), China Lake, California, and NAWCWD, Point Mugu, California.
2. Operational Evaluation. Operational Test (OT) OT-IIA was successfully completed in January 1987. OT-IIB was successfully completed in November 1988. OT-IIA and OT-IIB were conducted by Commander, Operational Test and Evaluation Force (COMOPTEVFOR) and Air Test and Evaluation Squadron Five (VX-5) at NAWCWD, China Lake, California.
F. EQUIPMENT/SYSTEM/SUBSYSTEM REPLACED. The IR Maverick does not replace any existing missiles in the Navy or Marine Corps inventory. Aircraft modifications to incorporate IR Maverick capability into the F/A-18, P-3C AIP, AV-8B, and A-6E SWIP aircraft have been completed.
G. DESCRIPTION OF NEW DEVELOPMENT. The U.S. Air Force is the executive service for development of the AGM-65 (series) Maverick Missile. In 1980, the U.S. Navy started development of the IR Maverick utilizing a modified IR tracker from the AGM-65D and the Center-Aft Section (CAS) from the AGM-65E.
1. Functional Description. The IR Maverick is an Infrared-guided, rocket-propelled, air-to-ground missile for use against targets requiring warhead penetration prior to detonation. The IR Maverick is a lock-on before launch, launch and leave missile. The missile is capable of two operator selectable modes of target tracking. The armor or land track mode is optimized for tracking land-based targets, such as tanks or fortified emplacements. The ship track mode is optimized for tracking seaborne targets. After launch, automatic missile guidance is provided by an IR energy sensing and homing seeker. The IR Maverick employs the Maverick Alternate Warhead (MAW) with a cockpit selectable delay fuze. The warhead is a kinetic energy penetrator and blast fragmentation warhead. The warhead fuze is initiated by a contact trigger and contains a fuze mechanism which delays arming until safely separated from the launch aircraft. The warhead fuze contains a selectable fuze time delay feature which permits a choice of surface detonation or detonation after penetration.
The LAU-117/A(V)2/A guided missile launcher is designed to carry and launch the AGM-65 E and F Maverick Missile. The launcher is delivered to the organizational level mated to the Maverick missile.
The Navy uses the CNU-447/E extruded aluminum container to ship the IR Maverick All-Up-Round (AUR) and CNU-472/E is used to ship the CAS. These containers is used to transport a repairable AUR and CAS to and from the AUR depot and Designated Overhaul Point (DOP), place Ready For Issue (RFI) AURs in storage, or transport RFI AURs back to the fleet. Damaged containers are repaired at the AUR depots, the DOP, and Naval Weapons Station (NWS) Seal Beach.
2. Physical Description. The AGM-65F Missile consists of a modified Air Force AGM-65D Guidance and Control Section (GCS) and the Navy AGM-65E CAS. The AGM-65F GCS contains software modifications to enhance its ship target tracking capability. The IR Maverick is shipped as an AUR. The dimensions, weight, and major sections are described below:
Length 97.7 inches
Diameter 12.0 inches
Stabilizer Span 28.5 inches
Weight (Prelaunch) 669.0 pounds
Weight (GCS) 110.0 + 1.25 pounds
Center of Gravity 47.6 inches aft of nose
a. Guidance and Control Section. The GCS contains the IR seeker, interface electronics, and rate sensor assemblies and dome. This section provides for target detection, tracking and missile guidance. The Navy IR GCS is capable of being interchanged on a one-for-one basis with the Laser Maverick GCS without changes to the missile center-aft-section.
b. Center-Aft Section. The CAS is comprised of the main structure and wing assembly, the Safety Arming Device, Warhead, Fuze and Fuze Delay Select Unit (FDSU), rocket motor, and the Hydraulic Actuation System (HAS).
c. Launcher (LAU-117/A(V)2/A). The major dimensions and weight are described below:
Length 94.5 inches
Width 11.0 inches
Height 11.0 inches
Weight 130 pounds
3. New Development Introduction. The IR Maverick was introduced as new production. Initial Operational Capability (IOC) for the IR Maverick was January 1991.
4. Significant Interfaces. The IR Maverick interfaces functionally and physically with the LAU-117/A(V)2/A Launcher and its associated test equipment. The launcher interfaces with the AV-8B, P-3C, and F/A-18 aircraft for electrical power and two-way data transfer between missile and cockpit controls and displays, and provides signals to the missile during captive carriage and for launch. The launcher also provides for missile restraint during aircraft catapult launches, arrested landings, and inadvertent rocket motor ignition.
H. CONCEPTS
1. Operational Concept. The IR Maverick does not replace any weapons in the current inventory. The AGM-65F IR Maverick Missile is designed primarily for use against targets requiring instantaneous or delayed blast fuzing for destruction of hardened ground and waterborne targets during day or night operations and in adverse weather conditions, with sufficient standoff range to permit limited exposures to terminal defenses. The IR Maverick does not replace any weapons in the current inventory.
2. Maintenance Concept. Maintenance of the IR Maverick employed on various aircraft is accomplished using the maintenance philosophy outlined in Naval Airborne Weapons Maintenance Program (NAWMP) OPNAVINST 8600.2 (Series).
a. Organizational Level. Organizational maintenance units receive an AUR mated to the launcher. Organizational maintenance is performed by Work Center 230 using Navy Aviation Ordnanceman (AO) personnel with Navy Enlisted Classification (NECs) 8342, 8843, 8319 and 8819, and Marine Corps personnel with Military Occupational Specialty (MOS) 6531. The AN/AWM-92 Aircraft Weapons Circuit Test Set is used at the organizational level to functionally test the aircraft weapons circuits prior to loading the IR Maverick. The AN/AWM-54 Firing Circuit Test Set and W-30 Igniter Adapter are used at the organizational level to perform stray voltage tests on the launcher igniter connector.
b. Intermediate Level. Intermediate Maintenance Activities Weapons Departments (shipboard, Naval Air Station (NAS) and MALS) receive AURs from the NWS, Marine Corps Air Station (MCAS), or Naval Airborne Weapons Maintenance Unit (NAWMU) and launchers from the supply system or AIMD. IR Maverick maintenance is performed by Weapons Department Navy AO personnel with NEC 6801 and Marine Corps personnel with MOS 6541. AIMD Work Center 710 Navy AO personnel with NECs 6802 and 6803 and USMC personnel with MOS 6541 functionally test the launcher using the A/E37T-35 Common Rack and Launcher Test Set (CRALTS). Weapons Department intermediate level maintenance tasks include:
· Visual inspection for damage and corrosion
· Perform corrosion control procedures
· Lubricate missile hook
· De-canning and canning of AUR
· Mating and de-mating of missile with launcher
· Prepare AUR for shipping or storage
· Deliver missile and launcher assembly to organizational level
· Return AUR to NWS, NAWMU, or MCAS
c. All-Up-Round Depot Level. NWS Seal Beach (Fallbrook Annex), California, NWS Yorktown, Virginia, and NAWMU One, Guam, are the depot level (AUR) maintenance activities. They are equipped with the TTU-519/E Guided Missile Test Set, the DSM-787 DSM IR Target Simulator, and maintenance handling equipment. Launchers are not processed through the NWSs or NAWMU. Depot level AUR maintenance tasks include:
· Receipt inspection
· Visual inspection for damage and corrosion
· Cleaning of external surfaces
· Touch-up painting on external surfaces
· Lubricate missile hook
· De-canning and canning of AUR
· Repair of minor structural damage
· Fault isolation by AUR test to faulty section
· GCS or CAS removal and replacement
· Recertification of AUR by retest
· Send faulty section to DOP
· Servicing of HAS reservoir
· Removal and replacement of piston actuator cover, hatch cover, fuselage door, HAS, and ground pin
DOP maintenance is performed at the Ogden Air Logistics Center (OO-ALC), Hill Air Force Base, Utah, in accordance with Depot Maintenance Inter-service Support Agreement number OO-ALC910 ANHD. OO-ALC repairs components that are beyond the capabilities of the NWS or NAWMU. OO-ALC is responsible for maintenance required to restore defective sections and repairable Shop Replaceable Assemblies (SRAs) to original acceptance standards. This includes test, fault isolation, repair of repairables, removal and replacement of defective components and non-repairable assemblies, corrective action verifications testing, and providing maintenance data to the cognizant surveillance program activity. DOP maintenance for GCSs is performed at Letterkenny Army Depot, Chambersburg, Pennsylvania.
d. Interim Maintenance. The IR Maverick has achieved full organic support. The Navy Support Date was September 1991.
e. Life Cycle Maintenance Plan. N/A
3. Manning Concept. The IR Maverick has no impact on existing manpower requirements at organizational, intermediate, or depot level activities. Pilot, Navy Flight Officer (NFO), and aircrew manpower is driven by seat factor and crew ratio. Enlisted manning for USN and USMC fleet squadrons, Fleet Readiness Squadrons, and intermediate maintenance activities is based on the total assigned workload, not only on specific IR Maverick requirements. Skills required to support the IR Maverick are considered to be within the capability of existing NECs and MOSs. Refer to Part II for existing USN and USMC intermediate maintenance manpower requirements.
4. Training Concept. The IR Maverick training concept is divided into organizational and intermediate level maintenance based on the philosophy outlined in Naval Airborne Weapons Maintenance Program (NAWMP) OPNAVINST 8600.2 (Series). Organizational level training is provided to operator and maintenance personnel. Operator training is provided for F/A-18 pilot and Weapons System Officer (WSO) personnel and for AV-8B pilots. Organizational level maintenance training is provided to AO personnel in the F/A-18 community with NECs 8342 and 8842 and MOS 6531, in the P-3 community with NEC 8319 and 8819 and in the AV-8B community with MOS 6531. Intermediate level training is provided to maintenance personnel with NEC 6801, and Marine Corps personnel with MOS 6541.
The established training concept for most aviation maintenance training divides "A" School courses into two or more segments called Core and Strand. The "C" School courses are also divided into separate Initial and Career training courses. "A" School Core courses include general knowledge and skills training for the particular rating, while "A" School Strand courses focus on the more specialized training requirements for that rating and a specific aircraft or equipment, based on the student's fleet activity destination. Strand training immediately follows Core training and is part of the "A" School. Upon completion of Core and Strand "A" School, graduates attend the appropriate Initial "C" School for additional specific training. Initial "C" School training is intended for students with a paygrade of E-4 and below. Career "C" School training is provided for E-5 and above personnel to enhance skills and knowledge within their field.
a. Initial Training. All initial training has been completed. No further initial training is planned.
b. Follow-on Training. Follow-on training for the IR Maverick is available as part of courses taught at Fleet Readiness Squadrons (FRSs), Maintenance Training Units (MTUs), Fleet Replacement Enlisted Skills Training (FREST) facilities, and Strike Fighter Weapons Schools (SFWSs). The IR Maverick causes no change in student throughput or chargeable student billets. Follow-on training courses have all been modified to include the IR Maverick and are currently on-line.
(1) Operator Training. Pilots and NFOs are trained at the appropriate FRS for specific aircraft operation. Operator skills in tactics and ordnance delivery are further enhanced at the SFWS and through on-board proficiency training. Training Devices (TDs) required for follow-on and proficiency operator training include the Part Task Trainer (PTT), the Captive Air Training Missile (CATM), and the Maverick Engagement Training Aid (META).
· Part Task Trainer. The PTT is a computer-based weapon system training device developed for use by F/A-18 aircrews. The PTT provides missile and operational procedures familiarization as well as proficiency training in launch and control techniques and will not take the place of formalized training.
· Training Guided Missile. The Training Guided Missile (TGM-A/A37A-T9) is an inert, captive flight-training missile permitting realistic exercise of the IR Maverick. The CATM airborne operation provides direct comparison with actual weapon firings by simulation without expending the missile.
· Maverick Engagement Training Aid. The META is a computer-based, interactive training software package designed for fleet use to assist aircrews in acquiring the necessary understanding of the IR Maverick and operational factors that affect weapon performance. The software currently runs on the Aviation Multi-function Electronic Warfare Trainer, and consists of a tutorial, an exercise generator, and an engagement scenario.
For detailed information on TDs and Training Aids refer to elements IV.A.2 and IV.B.2. The following table lists the applicable operator training courses. The IR Maverick source material has been incorporated in these courses with minimal impact. The IR Maverick causes no change in student throughput or chargeable student billets, and, therefore, these courses will not appear in Parts II and III.
| COURSE NUMBER | COURSE TITLE | RFT DATE INCLUDING IR MAVERICK |
| D/E-2A-0601 | F/A-18 Fleet Replacement Pilot Cat 1 | On-line |
| D/E-2A-0602 | F/A-18 Fleet Replacement Pilot Cat 2A | On-line |
| D/E-2A-0604 | F/A-18 Fleet Replacement Pilot Cat 3A | On-line |
| D/E-2A-0606 | F/A-18 Fleet Replacement Pilot Cat 4 | On-line |
| None (USMC) | F/A-18D Fleet Replacement Pilot Cat 1 | On-line |
| None (USMC) | F/A-18D Fleet Replacement Pilot Cat 2 | On-line |
| None (USMC) | F/A-18D Fleet Replacement Pilot Cat 3 | On-line |
| None (USMC) | F/A-18D Fleet Replacement Pilot Cat 4 | On-line |
| None (USMC) | F/A-18D (WSO) Cat 1 | On-line |
| None (USMC) | F/A-18D (WSO) Cat 2 | On-line |
| None (USMC) | F/A-18D (WSO) Cat 3 | On-line |
| None (USMC) | F/A-18D (WSO) Cat 4 | On-line |
| None (USMC) | AV-8B Pilot Basic | On-line |
| None (USMC) | AV-8B Pilot Transition | On-line |
| None (USMC) | AV-8B Pilot Conversion | On-line |
| None (USMC) | AV-8B Pilot Refresher | On-line |
| D-2A-1101 | P-3C and P-3C Update III Replacement Pilot Cat 1 | On-line |
| D-2A-1102 | P-3C and P-3C Update III Replacement Pilot Cat 2 | On-line |
| D-2A-1111 | P-3C and P-3C Update III Replacement Pilot Cat 1 TRK | On-line |
| D-2A-1113 | P-3C and P-3C Update III Replacement Pilot (PXO) CAT 3 Pipeline | On-line |
| D-2D-1101 | P-3C and P-3C Update III Replacement NFO Cat 1 | On-line |
| D-2D-1102 | P-3C and P-3C Update III Replacement NFO Cat 2 | On-line |
| D-2D-1107 | P-3C and P-3C Update III Post Command NFO Cat 4 | On-line |
| D-2D-1111 | P-3C and P-3C Update III Replacement NFO Cat 1 TRK | On-line |
| D-2D-1112 | P-3C and P-3C Update III Replacement NFO Cat 2 TRK | On-line |
| D-2D-1116 | P-3C and P-3C Update III Replacement NFO Cat 5 TRK | On-line |
| D-600-XXXB | P-3C and P-3C Update III AIP Pilot Transition Training | On-line |
| D-600-XXXD | P-3C and P-3C Update III AIP NFO Transition Training | On-line |
Note: SFWS LANT/PAC and MAWTS-1 provide aircrew tactics training.
(2) Organizational Maintenance. Weapon loading skills are further enhanced at SFWS, and through on-board proficiency training. TDs required for follow-on and proficiency training include the Training Guided Missile (TGM-A/A37A-T9) and the Dummy Guided Missile A/E37A-T60.
· Dummy Guided Missile. The Dummy Guided Missile A/E37A-T60 is physically representative of the IR Maverick. It is a training device to facilitate instruction and familiarization for transporting, handling, loading, and visual inspection procedures for organizational and intermediate level training purposes. The DATM is not certified for flight, and is designed for ground training use only.
For detailed information on TDs refer to element IV.A.2. The IR Maverick System will be taught in "A" school and in the following organizational level maintenance training courses. The IR Maverick source material has been incorporated in these courses with minimal impact. The IR Maverick causes no change in student throughput or chargeable student billets, and, therefore, these courses will not appear in Parts II and III.
| COURSE NUMBER | COURSE TITLE | TRACK NUMBER | RFT DATE INCLUDING IR MAVERICK |
| D/E-646-0640 | F/A-18 Conventional Weapons Loading | D/E-646-0653 | On-line |
| D/E-646-0647 | F/A-18 Conventional Release System Test | D/E-646-0653 | On-line |
| C-646-9888 | AV-8B Aircraft Ordnance Technician Integrated Organizational Maintenance | M-646-0143 | On-line |
| C-646-3893 | AV-8B Conventional Weapons Loading | M-646-0143 | On-line |
| D-646-1143/44 | P-3 Conventional Weapons Loading | D/E-646-1140 | On-line |
| C-646-3573 | P-3 Conventional Weapons Loading | D/E-646-1140 | Oct 99 |
Note: SFWS LANT/PAC provides USN and USMC F/A-18 loading training. FREST 203 provides AV-8B loading training. P3 loading training on the East Coast is provided by FASOTRAGULANT, and on the West Coast by NAMTRAGRU.
(3) Intermediate Maintenance. Intermediate maintenance training is available for Navy and Marine Corps Aviation Ordnance personnel through the appropriate MTU. The TD required for intermediate maintenance training is the Dummy Guided Missile A/E37A-T60. For detailed information refer to element IV.A.2.
The following courses have been updated to include IR Maverick data:
| Title .................... | Air Launched Guided Missiles Intermediate Maintenance |
| CIN .................... | C-122-3111 (part of D/E-646-7007) |
| Model Manager... | MTU 4030, Naval Air Maintenance Training Group Detachment (NAMTRAGRU DET) Norfolk |
| Description ......... | To provide ordnance personnel with knowledge of the Sparrow, Sidewinder, Phoenix, Sidearm, Shrike, Maverick, Harpoon, SLAM, HARM, Walleye, TALD, and Air Nitrogen Purifier Units. |
| Locations ............ | MTU 4032, NAMTRAGRU DET, NAS Norfolk
MTU 4033, NAMTRAGRU DET, NAS North Island MTU 4035, NAMTRAGRU DET, NAS Whidbey Island |
| Length ................ | 10 days |
| RFT date ............ | Currently available |
| Source rating ...... | AO |
| Skill identifier ..... | 6801 awarded upon completion of track D/E-646-7007 |
| TTE/TD ............. | Dummy Guided Missile A/E37A-T60 |
| Prerequisite ......... | AO A1 or equivalent |
| Title .................... | Aviation Ordnance Intermediate Maintenance Technician |
| CIN .................... | C-646-3105 (part of M-646-7026) |
| Model Manager... | VMAT-203 |
| Description ......... | To provide ordnance personnel with knowledge required by USMC personnel working on ordnance/armament. |
| Location ............. | VMAT-203 FREST, MCAS Cherry Point, North Carolina |
| Length ................ | 79 days |
| RFT date ............ | Currently available |
| Skill identifier ..... | MOS 6541 awarded upon completion of track M-646-7026 |
| TTE/TD ............. | Dummy Guided Missile A/E37A-T60 |
| Prerequisite ......... | Security clearance: Confidential |
(4) Explosive Ordnance Disposal Training. Explosive Ordnance Disposal Training is conducted at Naval Explosive Ordnance Disposal School (NAVSCOLEOD), Eglin Air Force Base (AFB), Florida. The TDs required for Explosive Ordnance Disposal (EOD) training are the Practical Explosive Ordnance Disposal System Trainer (PEST) and the Classroom Explosive System Trainer (CEST):
· Practical Explosive Ordnance Disposal System Trainer. The IR Maverick PEST is a full-scale model fabricated from actual hardware, having approximately the same weight and center of gravity as the tactical missile. The PEST is used for teaching Rendering Safe Procedures (RSP).
· Classroom Explosive System Trainer. The IR Maverick CEST is an inert cutaway model displaying locations and types of explosive and hazardous materials, initiators, igniters, and fuze. For further details on TDs see element IV.A.2.
The following table lists the applicable EOD training courses. The IR Maverick will be incorporated in these courses with minimal impact. This will cause no change to student throughput or chargeable student billets; therefore, these courses will not appear in Parts II and III.
| COURSE NUMBER | COURSE TITLE | RFT DATE |
| A-431-0011 | Explosive Ordnance Disposal Basic (Navy) | On-line |
| A-431-0012 | Explosive Ordnance Disposal Basic (Surface) | On-line |
| G-431-0001 | EOD Pre-deployment Team Training | On-line |
c. Student Profiles
| SKILL IDENTIFIER | PREREQUISITE SKILL AND KNOWLEDGE REQUIREMENTS |
| AO 6801 or MOS 6541 | C-646-2011, Aviation Ordnance "Class A1" School (Common Core)
and C-646-2012, Aviation Ordnance "Class A1" School (Airwing Strand) or C-646-2013, Aviation Ordnance "Class A1" School (Weapons Department Strand) |
d. Training Pipelines. The following training tracks apply and are available in the OPNAV Aviation Training Management System (OATMS):
| TRACK NUMBER | TRACK TITLE |
| D/E-646-7007 | Air Launched Guided Missiles Intermediate Maintenance |
| M-646-7026 | Aviation Ordnance Technician Intermediate Maintenance |
I. ON-BOARD (IN-SERVICE) TRAINING
1. Proficiency or Other Training Organic to the New Development
a. Maintenance Training Improvement Program. The Maintenance Training Improvement Program (MTIP) is used to establish an effective and efficient training system responsive to fleet training requirements. MTIP is a training management tool that, through diagnostic testing, identifies individual training deficiencies at the organizational and intermediate levels of maintenance. MTIP is the comprehensive testing of one's knowledge. It consists of a bank of test questions managed through automated data processing. The Deputy Chief of Staff for Training assisted in development of MTIP by providing those question banks (software) already developed by the Navy. MTIP was implemented per OPNAVINST 4790.2 series. MTIP allows increased effectiveness in the application of training resources through identification of skills and knowledge deficiencies at the activity, work center, or individual technician level. Refresher training is concentrated where needed to improve identified skill and knowledge shortfalls. (MTIP will be replaced by Aviation Maintenance In-Service Training (AMIST). List the timeframe for the NTSP here.)
b. Aviation Maintenance In-Service Training. Aviation Maintenance In-Service Training (AMIST) is intended to support the Fleet training requirements now satisfied by MTIP, and in that sense is the planned replacement. However, it is structured very differently, and will function as an integral part of the new Aviation Maintenance Training Continuum System (AMTCS) that will replace the existing aviation maintenance training structure. AMIST will provide standardized instruction to bridge the training gaps between initial and career training. With implementation of AMIST, technicians will be provided the training required to maintain a level of proficiency necessary to effectively perform the required tasks to reflect career progression. AMIST will begin when funding becomes available. AMIST will begin at Aircraft Intermediate Maintenance Departments in the forth quarter of FY00.
c. Aviation Maintenance Training Continuum System. AMTCS will redesign the aviation training process (training continuum), and introduce CBT throughout the Navy technical training process. The application and adoption of recent advances in computer hardware and software technology will enable CBT, with its basic elements of Computer Managed Instruction, Computer Aided Instruction, and Interactive Courseware, to be integrated into the training continuum and provide essential support for standardizing technical training.
d. Pilot and NFO Weapons Proficiency Training. Accomplished in three steps: Academic, Simulator, and Captive Carry:
· Academic. Selected squadron aircrewmen receive in depth classroom weapon training from an appropriate source (contractor, weapons school, etc.) to become the squadron subject matter expert on the selected weapon. The subject matter expert then returns to the squadron and holds academic training with the squadron aircrew. As an option to this step, all the squadron's aircrew would attend an academic class held at the appropriate weapons school to fulfill the academic requirement.
· Simulator. The appropriate weapons tactical trainer is set up by the squadron for the aircrewmen to gain required proficiency prior to captive carry of the selected weapon.
· Captive Carry. The selected training weapon is loaded on an aircraft at which time the aircrewmen will gain proficiency and final qualification on the selected weapon.
2. Personnel Qualification Standards. N/A
3. Other On-Board or In-service Training Packages.
Marine Corps onboard training is based on the current series of MCO P4790.12, Individual Training Standards System and Maintenance Training Management and Evaluation Program (MATMEP). This program is designed to meet Marine Corps, as well as Navy OPNAVINST 4790.2 series, maintenance training requirements. It is a performance-based, standardized, level-progressive, documentable, training management and evaluation program. It identifies and prioritizes task inventories by MOS through a front-end analysis process that identifies task, skill, and knowledge requirements of each MOS. MTIP questions coupled to MATMEP tasks will help identify training deficiencies that can be enhanced with refresher training. (MATMEP will be replaced by AMTCS in approximately FY02.)
The Conventional Weapon Technical Proficiency Inspection. (CWTPI) is a graded inspection administered by either Strike Fighter Weapons School Pacific or Atlantic. The CWTPI covers all areas of conventional weapon load and release, and control systems checks. The inspection evaluates the squadron's ability to correctly wire-check, upload & download conventional ordnance, use applicable publications, and place ordnance on its designated target. The squadron inspection is conducted annually, six months prior to deployment, or at the request of the squadron's Commanding Officer. A written examination is required by all personnel, including squadron pilots, directly involved in the inspection. The final grade is an average score derived from the written exams, ordnance loads, wire checks, and the pilots' proficiency to deliver weapons on target. Pre-inspection training is provided by the appropriate SFWS followed by the CWTPI. The CWTPI determines the need for further conventional weapons load training of squadron AO and Aviation Electronics Technician personnel at the appropriate SFWS. The P-3 community has a similar CWTPI administered by the appropriate Patrol Wing.
The USMC fighter-attack squadrons are scheduled by their respective Squadron Commanders for required biennially Marine Corps Combat Readiness Evaluation (MCCRE). This is part of the Marine Corps Combat Readiness Evaluation System. MCCREs may be completed during a 6-month period at the home base or at deployed sites. To complete an MCCRE, Operational Commanders have the option to move an entire Marine Corps activity to another location to participate in war exercises and be evaluated. Training is an on-going Marine Corps evolution that culminates with the Combat Readiness Evaluation. The evaluation determines the need for further conventional weapons load training of squadron personnel.
The United States Navy Explosive Safety Policies, Requirements, and Procedures (Department of the Navy Explosives Safety Policy Manual) OPNAVINST 8023.2 (Series), promulgates the Explosives Handling Personnel Qualification and Certification (QUAL/CERT) program. The QUAL/CERT program is designed to ensure that all Navy, Marine Corps, and civilians required to handle explosives or explosive devices are fully trained and qualified to perform all functions and task safety.
J. LOGISTICS SUPPORT
1. Manufacturer and Contract Numbers
| CONTRACT NUMBER | MANUFACTURER | ADDRESS |
| F33657-78-C-0468
F33657-86-C-2138 F33657-86-C-0130 F33657-88-C-0033 F33657-89-C-0003 F33657-89-C-0004 F33657-90-C-0020 |
Hughes Aircraft Company
Raytheon |
Tucson, Arizona
Bristol, Tennessee |
2. Program Documentation. The current Integrated Logistics Support Plan (ILSP) is ILSP No. MS-063, approved August 1991.
3. Technical Data Plan. Naval Air Systems Command (NAVAIRSYSCOM) has designated the Naval Air Technical Data and Engineering Command (NATEC) as the central agency for procurement and distribution control of technical manuals. As part of this responsibility, NATEC maintains an automated file of fleet and field publication requirements for each activity. Manuals required to support the IR Maverick are listed in Section 7.6 of ILSP No. MS-063. Manuals required for training are currently available and listed in element IV.B.3 of this NTSP.
4. Test Sets, Tools, and Test Equipment. Test set, tools, and test equipment required to support the IR Maverick are listed in section 7.4 of ILSP No. MS-063. The TTU-519/E Guided Missile Test Set is used in conjunction with the DSM-787 DSM IR Target Simulator at the AUR depots to test IR Maverick and Training Guided Missile (TGM-A/A37A-T9) missiles and fault isolate to a section (GCS or CAS).
The AN/AWM-92 Aircraft Weapons Circuit Test Set is used at the organizational level to functionally test the aircraft weapons circuits prior to loading the aircraft. The AN/AWM-54 Firing Circuit Test Set and W-30 Igniter adapter are used at the organizational level to perform stray voltage tests on the launcher igniter connector. The AN/AWM-90 Launcher Test Set is used at intermediate level activities to functionally test the launcher and fault isolate to an SRA. The AN/AWM-92, AN/AWM-54, and AN/AWM-90 are not unique to the IR Maverick.
5. Repair Parts. The IR Maverick supply support program is a joint effort between Navy and Air Force supply activities. Requirements for all levels of maintenance were identified and acquired during the provisioning process to ensure availability of spare and repair parts during the Initial Operating Capability and throughout the life-cycle. The Navy Inventory Control Point provides all common consumable and repairable items and acquires peculiar and unique consumable and repairable items for organizational and intermediate levels of maintenance by submitting a funded requisition to the Air Force. The Air Force will procure, stock, and issue unique depot level items in accordance with the Depot Maintenance Inter-service Support Agreement. The Navy Material Support Date was attained in first quarter FY92.
6. Human Systems Integration. N/A
K. SCHEDULES
1. Schedule of Events. Fleet introduction of the IR Maverick occurred in January 1991. All fleet deliveries are complete. The Navy Support Date was attained in September 1991. All training activities are currently RFT, except for Air Launched Guided Missiles Intermediate Maintenance C-122-3111 course at NAMTRAGRU Det (MTU-4035) Whidbey Island, which has a planned August 1999 RFT date.
a. Installation and Delivery Schedules. IR Maverick schedules are classified and are contained in the Weapon Systems Planning Document for the AGM-65F IR Maverick Missile System, NAVAIRNOTE C13100 of 5 January 1996.
b. Ready for Operational Use Schedule. The IR Maverick is currently considered to be ready for operational use.
c. Time Required to Install at Operational Sites. No time is required, since the IR Maverick is delivered as an All-Up-Round.
d. Foreign Military Sales and Other Source Delivery Schedules. Information on FMS deliveries must be obtained through PMA242.
e. Training Devices and Delivery Schedule. Since both the Laser Maverick and the Imaging Infrared (IR) Maverick are physically similar, all Dummy Guided Missile A/E37A-T60s will be collectively shared by activities for load drill training. Fifteen Dummy Guided Missile A/E37A-T60s and Thirty-nine Training Guided Missile TGM-A/A37A-T9s were initially delivered to the fleet. Element IV.A.2 of this NTSP contains information on locations of Training Devices as of March 1997. Current asset status and location can be obtained from the Conventional Ammunition Integrated Management System (CAIMS).
L. GOVERNMENT FURNISHED EQUIPMENT AND CONTRACTOR FURNISHED EQUIPMENT TRAINING REQUIREMENTS. N/A.
M. RELATED NTSPs AND OTHER APPLICABLE DOCUMENTS
| DOCUMENT
OR NTSP TITLE |
DOCUMENT
OR NTSP NUMBER |
PDA
CODE |
STATUS |
| AV-8B Harrier II Weapons System | A-50-8210D/A | PMA-257 | Approved
August 1994 |
| F/A-18 Weapon System | A-50-7703G/D | PMA-265 | Draft
June 1997 |
| AGM-65E Laser Maverick Missile System | A-50-8201C/A | PMA-242 | Approved
April 1999 |
| AGM-65E/F Laser/IR Maverick ILSP | ILSP NO: MS-063 | PDA AIR-3.1.1K | August 1991 |
| AGM-65E/F Laser/IR Maverick Phase Support Plan | PSP NO: MS-063 | AIR 3.1.1K | Approved
September 1991 |
| P-3C Update III Aircraft and AIP | A-50-8112B/D | PMA205-8B1 | Draft
May 1996 |
| Weapon System Planning Document for the AGM-65F IR Maverick Missile System | NAVAIRNOTE C13100 | PMA-242 | Approved
5 January 1994 |
|
NEWSLETTER
|
| Join the GlobalSecurity.org mailing list |
|
|
|
